| Common Name: | TKX ALL PURPOSE PENETRANT, LUBRICANT, PROTECTANT, 02016, 02022, 02028, 02005, 02 |
| Manufacturer: | LPS LABORATORIES |
| MSDS Revision Date: | 2/18/2004 |
| Grainger Item Number(s): | 4KK77 |
| Manufacturer Model Number(s): | 02016 |
MSDS Table of Contents
Click the desired link below to jump directly to that section in the MSDS.
LPS(R*)
LPS LABORATORIES
MSDS
MATERIAL SAFETY DATA SHEET
| SECTION 1 - PRODUCT IDENTIFICATION AND USE |  |
MANUFACTURER'S NAME: LPS LABORATORIES
STREET ADDRESS: 4647 HUGH HOWELL ROAD
CITY, STATE, ZIP: TUCKER, GA 30085-5052
TELEPHONE NUMBER: 770-934-7800
EMERGENCY TELEPHONE NUMBER: 1-800-424-9300 CHEMTREC
OUTSIDE U.S.: (703) 527-3887
TRADE NAME: TKX(R*) ALL PURPOSE PENETRANT, LUBRICANT, PROTECTANT
CHEMICAL FAMILY: PETROLEUM HYDROCARBONS
PART NUMBERS: 02016, 02022, 02028, 02005, 02055
HAZARDOUS MATERIALS DESCRIPTION AND PROPER SHIPPING NAME (49 CFR 172.101):
COMPOUND, BOILER, PRESERVING LIQUID
NMFC 50093 SUB 2 BRL/BXS CL55
CONSUMER COMMODITY ORM-D
TSCA INVENTORY: ALL OF THE INGREDIENTS ARE LISTED ON THE TSCA INVENTORY.
HMIS LABELING:
HEALTH 1
FLAMMABILITY 2
REACTIVITY 0
| SECTION 2 - HAZARDOUS INGREDIENTS / IDENTITY INFORMATION | |
INGREDIENTS CAS NUMBERS %WW OSHA PEL ACGIH OTHER
TLV LIMITS
ALIPHATIC HYDROCARBON 64742-47-8 60-70 N.E. N.E. 100 PEL
SUPPLIER
PETROLEUM OIL 64742-52-5 10-20 5MG/M3* 5MG/M3* 10 MG/M3*
(SEVERELY HYDROTREATED) STEL
3-METHOXY-3-METHYL-1- 56539-66-3 2-3 N.E. N.E. NONE
BUTANOL
CARBON DIOXIDE 124-38-9 2-3 10,000 5,000 30,000
PROPELLANT PPM PPM PPM STEL
(AEROSOL ONLY)
* OIL MIST
| SECTION 3 - PHYSICAL / CHEMICAL CHARACTERISTICS | |
BOILING POINT (DEG. F): 350 DEG. F
SPECIFIC GRAVITY (H2O = 1): 0.84
VAPOR PRESSURE (MMHg) @100 DEG. F: <2
PERCENT VOLATILE BY VOLUME (%): 70
VAPOR DENSITY (AIR = 1): 4.7
EVAPORATION RATE (n-BUTYL ACETATE = 1): .07
SOLUBILITY IN WATER: NIL
APPEARANCE AND ODOR: GREEN LIQUID WITH SLIGHT ODOR.
| SECTION 4 - FIRE AND EXPLOSION HAZARD | |
FLASH POINT (METHOD USED): 175 DEG. F SETA FLASH
FLAMMABLE LIMITS (OF DILUENT):
LEL: 1%
UEL: 6%
EXTINGUISHING MEDIA: FOAM, DRY CHEMICAL, CARBON DIOXIDE.
SPECIAL FIRE FIGHTING PROCEDURES:
DO NOT USE WATER. TREAT AS COMBUSTIBLE PETROLEUM DISTILLATES.
UNUSUAL FIRE AND EXPLOSIVE HAZARDS:
INTENSIVE HEAT CREATED BY FIRE WILL CAUSE AEROSOLS TO BURST.
| SECTION 5 - HEALTH HAZARD DATA | |
PRIMARY ROUTE(S) OF ENTRY: INHALATION, EYES
HEALTH HAZARD/EFFECTS OF OVER EXPOSURE:
INHALATION: HEADACHE, DIZZINESS, NAUSEA AND ANESTHETIC EFFECTS.
EYES: IRRITATION.
SKIN: REPEATED OR PROLONGED CONTACT MAY CAUSE DRYING OF SKIN.
INGESTION:
NOT A LIKELY ROUTE OF EXPOSURE. LOW ORDER OF ORAL TOXICITY; HOWEVER MINUTE
AMOUNT ASPIRATED INTO LUNGS DURING INGESTION MAY CAUSE SEVERE PULMONARY
INJURY.
MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE: NONE FROM NORMAL EXPOSURE.
CHEMICALS LISTED AS POTENTIAL CARCINOGEN:
NTP: NO
IARC: NO
OSHA: NO
EMERGENCY AND FIRST AID PROCEDURES:
INHALATION: MOVE TO FRESH AIR. CONTACT PHYSICIAN.
EYES: FLUSH EYES WITH PLENTY OF WATER AND CONTACT PHYSICIAN.
SKIN: WASH WITH SOAP AND WATER; APPLY MEDICATED SKIN CREAM.
INGESTION:
CONTAINS ALIPHATIC HYDROCARBONS AND PETROLEUM OIL. DO NOT INDUCE VOMITING.
CONTACT PHYSICIAN IMMEDIATELY.
| SECTION 6 - REACTIVITY DATA | |
STABILITY: STABLE
CONDITIONS TO AVOID:
AVOID SPARKS OR OPEN FLAMES. SEE HANDLING AND STORAGE PRECAUTIONS.
INCOMPATIBILITY (MATERIALS TO AVOID): STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
THERMAL DECOMPOSITION MAY YIELD CARBON MONOXIDE.
HAZARDOUS POLYMERIZATION: WILL NOT OCCUR.
| SECTION 7 - PRECAUTIONS FOR SAFE HANDLING AND USE | |
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED:
VENTILATE AREA BY OPENING DOORS AND WINDOWS. REMOVE IGNITION SOURCES. REMOVE
LEAKING CONTAINER AND TRANSFER REMAINING PRODUCT TO ANOTHER VESSEL. PREVENT
PRODUCT FROM GOING INTO SEWERS AND WATER SOURCES BY DIKING OR IMPOUNDING.
USING APPROPRIATE SAFETY EQUIPMENT, MOP UP OR SOAK UP WITH ABSORBENT
MATERIAL, SUCH AS SAND OR CLAY.
WASTE DISPOSAL METHODS:
DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS FOR
PETROLEUM DISTILLATES.
RCRA HAZARDOUS WASTE NO.: N.A.
CERCLA REPORTABLE QUANTITY: NONE
SARA TITLE III CHEMICALS: NONE
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORAGE:
STORE AEROSOLS BELOW 120 DEG. F AND ABOVE 32 DEG. F. STORE AWAY FROM
IGNITION SOURCES AND AVOID BREATHING VAPORS.
| SECTION 8 - CONTROL MEASURES | |
RESPIRATORY PROTECTION:
NONE REQUIRED IF GOOD VENTILATION IS MAINTAINED. FOR ENCLOSED AREAS, USE
NIOSH APPROVED ORGANIC VAPOR CARTRIDGE RESPIRATOR OR SELF-CONTAINED
BREATHING APPARATUS.
VENTILATION:
LOCAL EXHAUST IS USUALLY ADEQUATE. HOWEVER, MECHANICAL VENTILATION SHOULD BE
USED WHEN SPRAYING IN ENCLOSED AREAS. VAPOR CONCENTRATION SHOULD BE
MINIMIZED AS MUCH AS POSSIBLE.
PROTECTIVE GLOVES: USE NBR OR NITRILE GLOVES FOR LIQUID HANDLING.
EYE PROTECTION:
FOR SPRAYING OR SPLASHING OF SOLVENT, USE FACE SHIELD OR GOGGLES.
OTHER PROTECTIVE EQUIPMENT: NONE.
WORK/HYGIENIC PRACTICES:
WASH HANDS WITH SOAP AND WATER AFTER USE AND/OR BEFORE BREAKS, LUNCH AND AT
THE END OF WORK PERIODS. REMOVE CONTAMINATED CLOTHING AND LAUNDER BEFORE
REUSE.
| SECTION 9 - PREPARATION DATE OF MSDS | |
THE FOREGOING TECHNICAL INFORMATION AND RECOMMENDATIONS ARE COMPILED FROM
SOURCES THAT ARE BELIEVED TO BE ACCURATE AND RELIABLE. HOWEVER, THEY ARE
SUPPLIED WITHOUT WARRANTY OR GUARANTEE OF ANY KIND EITHER EXPRESSED OR
IMPLIED. THE PURCHASER IS RESPONSIBLE FOR SELECTING AND DETERMINING THE
SUITABILITY OF PRODUCTS FOR PURCHASER'S PARTICULAR NEEDS AND WE DISCLAIM ANY
RESPONSIBILITY FOR IMPROPER APPLICATIONS OR MISUSE OF OUR PRODUCTS IN ANY
MANNER WHATSOEVER.
FEBRUARY 18, 2004
FRED FUGITT, TECHNICAL SERVICES CHEMIST
ED WILLIAMS, MANAGER OF RESEARCH AND DEVELOPMENT
LPS LABORATORIES
FORM #2590
N.E. = NOT ESTABLISHED
N.A. = NOT APPLICABLE
ITW