SHERWIN WILLIAMS SPECIALTY DIVISION -- 00340 GRAY RUST CONTROL  -- 8010-00F039474
<pre>=====================  Product Identification  =====================

Product ID:00340 GRAY RUST CONTROL
MSDS Date:12/01/1992
FSC:8010
NIIN:00F039474
=== Responsible Party ===
Company Name:SHERWIN WILLIAMS SPECIALTY DIVISION
Address:26300 FARGO AVE
City:BEDFORD HTS
State:OH
ZIP:44146-1370
Country:US
Info Phone Num:216-292-7400/800-777-2966
Emergency Phone Num:800-777-2966/216-292-7400
CAGE:54626
=== Contractor Identification ===
Company Name:SHERWIN WILLIAMS COMPANY
Address:101 PROSPECT AVE NW
City:CLEVELAND
State:OH
ZIP:44115
Country:US
Phone:216-566-2902
CAGE:54626
Company Name:SHERWIN-WILLIAMS DIVERSIFIED BRANDS, INC.
Address:26300 FARGO AVENUE
Box:City:BEDFORD HEIGHTS
State:OH
ZIP:44146
Country:US
Phone:216-292-7400 OR 216-595-8634
CAGE:09800

=============  Composition/Information on Ingredients  =============

Ingred Name:TOLUENE (IARC CARC- GROUP 3)     *95-1*
CAS:108-88-3
RTECS #:XS5250000
Fraction by Wt: 5%
Other REC Limits:375 MG/CUM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:XYLENE, DIMETHYLBENZENE, XYLOL     (IARC - GROUP 3)  *95-1*
CAS:1330-20-7
RTECS #:ZE2100000
Fraction by Wt: 13%
Other REC Limits:100 PPM
OSHA PEL:100 PPM
ACGIH TLV:100 PPM, SKIN
EPA Rpt Qty:1000 LBS
DOT Rpt Qty:1000 LBS

Ingred Name:SOLVENT NAPHTHA, PETROLEUM, LIGHT AROMATIC, HIGH FLASH
    AROMATIC NAPHTHA
CAS:64742-95-6
RTECS #:WF3400000
Fraction by Wt: 2%
ACGIH TLV:100 PPM

Ingred Name:ACETONE; DIMETHYL KETONE; 2-PROPANONE
CAS:67-64-1
RTECS #:AL3150000
Fraction by Wt: 40%
OSHA PEL:750 PPM
ACGIH TLV:750 PPM
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

Ingred Name:TALC (POWDER), (ASBESTOS FREE), TALCUM; HYDROUS MAGNESIUM
    SILICATE
CAS:14807-96-6
RTECS #:WW2710000
Fraction by Wt: 4%
OSHA PEL:2 MG/CUM
ACGIH TLV:2 MG/CUM (RESP DUST)

Ingred Name:BARIUM SULFATE, BARYTES
CAS:7727-43-7
RTECS #:CR0600000
Fraction by Wt: 5%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM

Ingred Name:TITANIUM DIOXIDE, TIO2 (SUSPECTED ANIMAL CARCINOGEN, IARC
    GROUP 3) *95-1*
CAS:13463-67-7
RTECS #:XR2275000
Fraction by Wt: 2%
OSHA PEL:10 MG/CUM
ACGIH TLV:10 MG/CUM (DUST)

Ingred Name:PROPANE
CAS:74-98-6
RTECS #:TX2275000
Fraction by Wt: 15%
Other REC Limits:1800 MG/CUM
OSHA PEL:1000 PPM
ACGIH TLV:SIMPLE ASPHYXIANT

Ingred Name:KEROSENE (PETROLEUM), HYDROTREATED (C10-C15 SATURATED
    HYDROCARBONS 97%, C10 AROMATICS 3%)   *95-1*
CAS:64742-47-8
RTECS #:OA5504000
Fraction by Wt: 2%
Other REC Limits:200 PPM EXXON
OSHA PEL:100 PPM
ACGIH TLV:100 PPM

=====================  Hazards Identification  =====================

Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:NO
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:IRRITATION OF EYES, SKIN & RESPIRATORY
    TRACT. MAY CAUSE NERVOUS SYSTEM DEPRESSION. EXTREME OVEREXPOSURE
    MAY RESULT IN DEATH. PROLONGED OVEREXPOSURE TO SOLVENTS MAY CAUSE
    PERMANENT BRAIN/NERVOUS SYSTEM  DAMAGE & ADVERSE EFFECTS TO
    LIVER/URINARY/BLOOD-FORMING/CARDIOVASCULAR & REPRODUCTIVE SYSTEMS.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, UNCONSCIOUSNESS, HEADACHE,
    DIZZINESS, NAUSEA, LOSS OF COORDINATION, REDNESS, ITCHING, BURNING
    SENSATION.

=======================  First Aid Measures  =======================

First Aid:INHALATION: REMOVE TO FRESH AIR. RESTORE BREATHING, KEEP WARM
    & QUIET. SKIN: WASH AFFECTED AREA THOROUGHLY W/SOAP & WATER. EYES:
    FLUSH W/LARGE AMOUNTS OF WATER FOR 15 MINS. INGESTION: NEVER GIVE
    ANYTH ING BY MOUTH TO AN UNCONSCIOUS PERSON. DON'T INDUCE VOMITING.
    GIVE SEVERAL GLASSES OF WATER. OBTAIN MEDICAL ATTENTION IN ALL
    CASES.

=====================  Fire Fighting Measures  =====================

Flash Point Method:PMCC
Flash Point:<0F
Lower Limits:1
Upper Limits:12.8
Extinguishing Media:CO2, DRY CHEMICAL, FOAM.
Fire Fighting Procedures:WEAR SCBA & FULL PROTECTIVE EQUIPMENT. WATER
    SPRAY MAY BE INEFFECTIVE, BUT MAY BE USED TO COOL CLOSE CONTAINERS.
    IF WATER IS USED, FOG NOZZLES ARE PREFERABLE.
Unusual Fire/Explosion Hazard:CLOSED CONTAINERS MAY EXPLODE WHEN
    EXPOSED TO EXTREME HEAT. VAPORS WILL ACCUMULATE READILY & MAY
    IGNITE EXPLOSIVELY. EXTREMELY FLAMMABLE.

==================  Accidental Release Measures  ==================

Spill Release Procedures:REMOVE ALL IGNITION SOURCES. VENTILATE &
    REMOVE W/INERT ABSORBENT.

======================	Handling and Storage  ======================

Handling and Storage Precautions:KEEP FROM IGNITION SOURCES. DURING USE
    & UNTIL VAPORS ARE GONE, KEEP AREA VENTILATED. DON'T SMOKE & REMOVE
    IGNITION SOURCES. CONTENTS UNDER PRESSURE.
Other Precautions:AVOID BREATHING VAPOR/SPRAY MIST. AVOID CONTACT
    W/SKIN & EYES. CONSULT NFPA CODE. USE APPROVED BONDING/GROUNDING
    PROCEDURES. DON'TPUNCTURE/INCINERATE/EXPOSE TO TEMPS >120F. DON'T
    TAKE INTERNALLY. KEEP  OUT OF REACH OF CHILDREN.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:WEAR A PROPERLY FITTED NIOSH/MSHA APPROVED
    ORGANIC VAPOR/PARTICULATE RESPIRATOR IF EXPOSURE CAN'T BE
    CONTROLLED <APPLICABLE LIMITS BY VENTILATION. WEAR A DUST/MIST
    RESPIRATOR WHEN SANDING/ABRADING DRI ED FILM.
Ventilation:LOCAL EXHAUST: PREFERABLE. GENERAL EXHAUST: ACCEPTABLE IF
    EXPOSURE IS MAINTAINED <APPLICABLE EXPOSURE LIMITS.
Protective Gloves:REQUIRED
Eye Protection:SAFETY GLASSES W/UNPERFORATED SIDESHIELD
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
    REUSE. WASH AFTER HANDLING.
Supplemental Safety and Health
INTENTIONAL MISUSE BY DELIBERATELY CONCENTRATING & INHALING CONTENTS
    CAN BE HARMFUL/FATAL.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:<0-395F
Vapor Density:>1
Evaporation Rate &amp; Reference:FASTER THAN ETHER
Appearance and Odor:GRAY
Percent Volatiles by Volume:>75

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
HOT WATER.
Stability Condition to Avoid:SUNLIGHT, EXTREME HEAT, TEMP >120F,
    SPARKS, OPEN FLAME & OTHER IGNITION SOURCES.
Hazardous Decomposition Products:CO, CO2, METAL OXIDES.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DON'T INCINERATE. DEPRESSURIZE CONTAINER.
    DISPOSE OF IAW/FEDERAL, STATE & LOCAL REGULATIONS. WASTE MUST BE
    TESTED FOR IGNITABILITY TO DETERMINE APPLICABLE EPA HAZARDOUS WASTE
    NOS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.